Link to custom tool:

After pulling the oil dipstick, you could smell the diesel fuel in the oil. It was determined that to cure the fuel leaking into the oil it would be best to replace all eight, injectors with new Bosch (PN0986435502 #19) fuel injectors. Follow along as Domestic Diesel’s Chris Greenberg properly removed and installed all-new Bosch fuel injectors.

A video of changing the driver side fuel injector leaking copper seals. This is the same job as replacing the injectors. Applies to all vehicles that have

Start by using a ratchet wrench and socket to remove the bolts keeping the valve cover over the engine block. Once you remove these bolts, you should place the valve cover aside. 2. Remove Exhaust Manifold. Take the exhaust manifold off the engine by removing your six hex-head bolts.
However, early Duramaxes aren't problem free. The biggest issue with '01-to-'04 and 1/2 LB7 engines is their fuel injectors' propensity to fail, typically before an engine reaches 100,000 miles
Loosen plug on back of head to drain fuel. Remove intercooler tube and valve cover. Unplug injector and remove oil deflector on top side 8mm bolt. Remove 8mm bolt on lower side. pry up on injector to remove. Oil will drain into cylinder. I use a vacuum evac system to suction the oil out. You can stuff a rag in and absorb as much as possible. How To Install DT466 Injectors. If you have removed the injectors, then you have all the hard work done. All the parts in the way have been removed and set aside. All you have to do is put the new injectors in the old one's place and use your torque wrench to get the right amount of torque.
Step 7 - Remove the Injector. Using the same wrench, pull out the injector carefully and gently. Remove the rear most injector first. Make sure that the injector is pulled straight out of the bore in relation to the bore's direction, lifting the injector at an angle can wedge the injector inside the bore. Now place the injectors on a suitable
The Ford 2000 tractor is Smokey and smells of raw Unburnt diesel. Let’s see if new injectors will help with that issue. The Ford 2000 tractor is Smokey and smells of raw Unburnt diesel. Let’s gcTmnX.
  • a3lb1g0ow7.pages.dev/625
  • a3lb1g0ow7.pages.dev/673
  • a3lb1g0ow7.pages.dev/285
  • a3lb1g0ow7.pages.dev/969
  • a3lb1g0ow7.pages.dev/964
  • a3lb1g0ow7.pages.dev/792
  • a3lb1g0ow7.pages.dev/625
  • a3lb1g0ow7.pages.dev/882
  • a3lb1g0ow7.pages.dev/784
  • a3lb1g0ow7.pages.dev/656
  • a3lb1g0ow7.pages.dev/267
  • a3lb1g0ow7.pages.dev/211
  • a3lb1g0ow7.pages.dev/742
  • a3lb1g0ow7.pages.dev/629
  • a3lb1g0ow7.pages.dev/652

    • how to change diesel fuel injectors